“Main propulsion develops about 230,000lbs (1,000kN) at lift off using 90% concentration hydrogen peroxide and kerosene as propellants,” says the report.
It also explains that the crew capsule has a solid rocket launch abort system to separate it from the propulsion module.
The flight profile will see the vehicle fire its engine for 2min reaching 125,000ft (38,000m) altitude. Then its momentum would see it coast to at least 100km (54nm) before returning to Earth.
The report states that Bezos claims that the crew capsule and propulsion module may separate at this point or may return as a single vehicle.
Without the separation the whole system lands under power as the main engines reignite for about 15s just before landing.
If separation occurs the crew capsule would land using parachutes while the propulsion system descends under power.
The FAA report says the launch site will have a vehicle processing facility, a launch complex, a vehicle landing and recovery area and a spaceflight participant training facility.
Blue Origin proposes to conduct a test flight programme over the next five years at its Corn Ranch launch site, detailed in the table below.
|BLUE ORIGIN FLIGHT TEST PROGRAMME|
||The majority of facility construction at the site would occur during this period. In the third and fourth quarters of 2006, Blue Origin would ship the first prototype low-altitude test vehicle to the site and conduct the first flight tests. Ten or fewer flight tests could be conducted in 2006, each to an altitude of approximately 2,000ft (610m) for less than 1min.|
||Continued flight testing of prototype vehicles with incrementally increasing capability. During these years, Blue Origin proposes to gradually expand the operational envelope of its vehicles, conducting 25 or fewer launches per year. A wide range of tests are anticipated, ranging in altitude from under 2,000ft to greater than 325,000ft, lasting 1min or less to over 10min. Development tests of the crew capsule abort system would be conducted during this time frame. Some construction to upgrade the facility would also occur, adding additional infrastructure to support the increasing capabilities of the system.|
||Commercial operations may commence with the operational New Shepard vehicle in this timeframe. The flight rate would depend on market demand, but Blue Origin anticipates rates up to approximately 52 launches per year of the New Shepard relaunchable launch vehicle.|